Opel Corsa B, Combo, Tigra

Since 1993-2000 of release

Repair and car operation



Opel Corsa B, Combo, Tigra
+ Cars Opel Corsa B, Tigra and Combo
+ Controls and operation receptions
- Options and car routine maintenance
   The routine maintenance schedule
   The general information
   The general data on options and adjustments
   Checks of levels of liquids
   Check of a condition of tyres and pressure of their rating, rotation of wheels
   Replacement of impellent oil and the oil filter
   Check of a condition and replacement of a belt of a drive of auxiliary units
   Removal of a sediment from the fuel filter of the diesel engine
   Check of a condition and replacement of the hoses located in an impellent compartment
   Check of a condition of components
   Check, service and gymnastics
   Check of a condition and replacement of brushes
   Check of system of release of the fulfilled gases
   Check of brake system
   Electric equipment check
   The control of a condition of an anticorrosive covering of a body and the car bottom
   Check and adjustment of turns of idling and the maximum turns
   Replacement of a filtering element
   Check and service
   Replacement of the fuel filter
   Check of structure of the fulfilled gases
   Greasing of locks, loops and emphasis
   Survey of components of a suspension bracket
   Check and adjustment клапанных backlashes on the diesel engine
   Replacement of spark plugs
   Check of adjustment of a pedal of coupling
   Replacement of a brake liquid
   Replacement ATF
+ Engines
+ Systems of cooling of the engine, salon and air conditioning heating
+ Power supply systems, release and decrease in toxicity of the fulfilled gases
+ Systems of an electric equipment of the engine
+ Manual 5-step box of a gear change
+ Automatic 4-step transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment



Removal of a sediment from the fuel filter of the diesel engine

Release on 08.1997 - every year, release with 09.1998 - each 2 years.

Before the beginning of performance of any procedures of service of the fuel filter carefully wipe a surface round a place of its landing for the purpose of prevention of risk of hit of a dirt in a power supply system path. For gathering of spilt fuel enclose under the filter rags, or establish suitable drain capacity.

Do not suppose hit of diesel fuel on surfaces of the generator, a starter, hoses of system of cooling, a support of the engine and electroconducting plaits!

The fuel filter is established in a forward left corner of an impellent compartment, near to tank GUR.

 PERFORMANCE ORDER

  1. Liberate a drain hose from the holder and direct it downwards.

The gate of descent of fuel from the fuel filter (the bottom arrow), - for the purpose of simplification вытекания fuel it is possible to weaken the cover screw (the top arrow)

  1. Substitute under a hose capacity for water gathering.
  2. Ослабьте the gate below on the filter also allow fuel to flow down in the prepared capacity. Do not close the gate until pure fuel will not start to follow from a hose, - it is usually enough to merge about 100 ml.

For the purpose of maintenance of more free вытекания fuel ослабьте the screw of prorolling screwed in the top part of a cover of the filter.

  1. Accurately tighten the gate, remove from it a hose and clean drain capacity. Pure rags collect traces of the spilt fuel. In case of need accurately tighten the top screw of a cover.
  2. In summary carefully collect the rests of the spilt fuel and check up all weakened components on presence of signs of development of leaks.
  3. Start the engine and pump over fuel system (see the Head of the Power supply system, release and decrease in toxicity of the fulfilled gases).